Annual Fuel Utilization Efficiency (AFUE): 年度燃料利用效率(AFUE)评级, 指示熔炉将能量转化为可用热量的好坏程度. 额定值表示为年输出热量的百分比(输出额定值单位为Btus——英国热单位), (一种能量计量)到炉内每年输入的能量(输入额定值,单位为btu).
Ratings can be categorized in the following way:
Ratings between 84 and 89 百分比 are not common. 酸性凝结水以这些百分比形成,对熔炉有害. 公法不. 100-12, 通过年, 要求1月1日后生产的所有煤气炉, 1992, have a minimum AFUE of 78 百分比.
Atmospheric Vent Combustion: 如果有烟囱,安装这种系统的熔炉是最便宜的. Atmospheric vent furnaces have AFUEs of 60-65 百分比 when equipped with standing pilots, and AFUEs of 63-70 百分比 when equipped with electronic ignition systems. 与特殊的排气阻尼器,大气排气单元可以实现 AFUEs of 78-80 百分比.
Condensing (or Recuperative Units): 这些单位是超级高效的一些设计达到 AFUEs of up to 97 百分比. Unlike conventional forced air furnaces, 冷凝装置捕获了通常从烟囱中逸出的热烟道气体中的大部分水蒸气和热量. 逸出的气体然后通过第二个热交换器和冷凝液被排出. 热交换器采用耐腐蚀不锈钢制造, and many have lifetime warranties. 排气温度比传统的熔炉低,可以通过PVC管道排气.
Downflow or Counterflow Furnace: 这些装置的顶部有一个鼓风机,将空气吸入熔炉. Heated air is blown out at the bottom. 这种类型的炉子是用来供应地板管道系统的.
Electronic Ignition: 电子点火装置消除了对能源浪费的站立飞行员的需要. Fuel is used only when needed. The pilot is ignited with an electric spark.
热交换器: 热交换器是炉膛内的金属室,里面装有燃气燃烧器. The flame produced by the burner heats the chamber. When the outside of the chamber becomes hot, 它周围的空气被加热,用来给房子供暖. 改进的设计提高了效率和提供更安静的操作.
Horizontal Flow Furnace: 空气从加热器的一侧水平流动, across the heat exchanger, and hot air is blown out the other side. 这种类型的炉子安装在空间有限的地方,如阁楼或爬行空间. 它们也可以安装在地板下面或悬挂在天花板下面.
Non-weatherproof: These units are designed to be installed indoors.
权力燃烧: In this system, combustion is produced by a blower. 鼓风机推动燃烧气体通过排气口,并调节燃烧空气的量. 动力燃烧炉不需要通风罩. 这减少了非循环损耗,提高了效率. Many power combustion furnaces operate at 78 - 80年AFUE百分比. 当配备额外的热交换器时,它们可以在 AFUEs of 90-96 百分比.
脉冲燃烧: (These models are listed under condensing furnaces.脉冲燃烧是由自我延续的“脉冲”产生的.“这种独特的系统在密封的燃烧室中混合空气和燃料. 一个火花点燃了混合物,并导致压力增加关闭气体/空气进口阀门. 燃烧产物被迫通过排气管,燃烧室内的压力下降, re-opening the inlet valve. 下一个燃烧循环是由前一个循环剩余的热量点燃的. 这个过程大约每秒重复60次. Furnaces with this combustion system have AFUEs from 91-97 百分比. 在100-200华氏度的温度下,废气足够冷,可以通过PVC管道排出.
密封燃烧: 密封燃烧系统从外部吸入所有用于燃烧的空气, 废气直接排到室外. 因为在燃烧过程中,室外寒冷的空气不会与室内温暖的空气混合, efficiency is enhanced. 这种燃烧系统的炉子有一个 AFUE范围70-80 百分比.
上升气流炉: 这些设备的底部有鼓风机,将空气吸入熔炉. Heated air is blown out at the top. 这些加热器可以安装在杂物间、壁橱或地下室.
通风器: 排气挡板是安装在烟道内的“挡板”装置. When the heat demand has been met, 阻尼器关闭, 捕获余热在家中循环. 当需要热量时, 在点燃燃烧器之前,风门打开,使燃烧烟气逸出. 只有燃烧器打开时,风门才会保持打开状态. Burners cannot ignite if the damper is closed.
不受天气影响的: These units are designed to be installed outdoors.
定义由全国丙烷气体协会提供